Kohler Aegis LV680 Bedienungsanleitung

KOHLER AEGIS®LV625, LV675, LV680LIQUID-COOLEDVERTICAL CRANKSHAFTOWNER'S MANUAL

10Cooling System Maintenance and ServiceImportant service notes:• Do not operate the engine without coolant insystem.• Do not remove the radiator cap

11Draining Cooling System1. Stop the engine and allow it to cool sufficiently.2. Unhook the four retaining straps, and remove theupper blower housing

127. Reinstall the reservoir, engaging the two lowermolded protrusions in the mounting holes of thesupport bracket. Engage the top bracket aroundthe u

13Service PrecleanerWash and reoil the precleaner every 25 hours ofoperation (more often under extremely dusty or dirtyconditions).1. Unhook the four

14Clean Air Intake/Cooling AreasTo ensure proper air circulation, make sure the airintake screen, radiator, cooling fins, and other externalsurfaces o

15Ignition SystemThis engine is equipped with an electronic CD ignitionsystem. Other than periodically checking/replacing thespark plugs, no maintenan

16Carburetor Troubleshooting andAdjustmentsIn compliance with the government emissionstandards, the carburetor is calibrated to deliver thecorrect fue

17Dirty AirPossible Cause No Improper Dirt In Intake Screen Incorrect Engine Dirty Air FaultyProblem Fuel Fuel Fuel Line or Radiator Oil Level Overloa

18SpecificationsModel: ...LV625 ...LV675

19KOHLER CO.FEDERAL AND CALIFORNIA EMISSION CONTROL SYSTEMSLIMITED WARRANTYSMALL OFF-ROAD ENGINESThe U.S. Environmental Protection Agency (EPA), the C

2CaliforniaProposition 65 WarningSafety PrecautionsEngine exhaust from this productcontains chemicals known to theState of California to causecancer,

LIMITATIONSThis Emission Control Systems Warranty shall not cover any of the following:(a) repair or replacement required because of misuse or neglect

3Carbon Monoxide can causesevere nausea, fainting or death.Do not operate engine in closed orconfined area.WARNINGWARNINGExplosive Gas can cause fires

4Oil Fill/DipstickElectricStarterEngineIdentification LabelSpark PlugValve Cover withIntegral BreatherOil FilterFuelPumpSparkPlugUpper Blower Housing

5Do not use gasoline left over from the previous season,to minimize gum deposits in your fuel system and toensure easy starting.Do not add oil to the

6Pre-Start Checklist• Check oil level. Add oil if low. Do not overfill.• Check coolant level. Add coolant if low.• Check fuel level. Add fuel if low.•

7BatteryA 12 volt battery is normally used. Refer to theoperating instructions of the equipment this enginepowers for specific battery requirements.If

8Maintenance InstructionsMaintenance, repair, or replacement of the emission control devices and systems, which are being done atthe customers expense

9Figure 6. Oil Level Dipstick.5. If the level is low, add oil of the proper type, up tothe “FULL” mark on the dipstick. (Refer to “OilType” on page 4.